Logansport firefighters spent six hours Tuesday on the scene of a sawdust fire at Cole Hardwood.
Assistant Chief Dave Huff said he was unsure what ignited the highly combustible material. Upon arrival just before 10 a.m., he was concerned about the nature of burning sawdust inside a silo. He said pressure can build up to the point it can cause an explosion.
“You can’t send anybody inside those things because it’s just way too dangerous,” Huff said. “If one of those things explode, it can be one heck of an explosion.”
Randy Cole, co-owner of the lumber company, said workers heard a loud boom from pressure forcing the lids off port holes atop a silo partially filled with sawdust. Cole said the safety valves served their function.
“I’m just happy that no one got hurt,” Cole said as he looked on while firefighters shot water in from two sides at the base of the silo.
The fire melted paint off most of the white storage bin, which stands about as tall as the City Building.
After returning to station about 4 p.m., Huff talked about the challenges presented with fighting a fire inside a 42,000 cubic feet storage bin.
The silo had an auger running down the middle, and it was sectioned off into five or six levels divided by floors, permitting only limited access to the fire, Huff said.
Firefighters surrounded the silo with trucks, opened up doors and portholes near ground level and sprayed an estimated 200,000 gallons of water inside.
“It could have been a lot worse,” Huff said. “It’s bad enough the way it is. Nobody got hurt, and that’s what counts.”
Monticello firefighters were called in for assistance because Logansport’s ladder truck was out of service with mechanical problems. Cole expressed thanks to Monticello for sending the truck.
“We appreciate that very much,” he said.
Cole explained that the business burned the sawdust to create steam heat, which is used to dry lumber and maintain a controlled-temperature setting in hardwood storage areas. Without a full investigation, he said, he could not determine whether the silo was a total loss. Most of the water-logged sawdust went down the drain.
As sawdust and water poured from the silo, a nearby parking lot flooded. Water reached several inches deep before sawdust was cleared from the drain.
Huff said the metal siding expanded and might have compromised its strength. Also, a cable holding up the dust collector unit, or baghouse, on top of the silo broke, causing the entire thing to lean.
Cole said the fire did not slow production at either Cole Hardwood or IDI, but he said it did cause a slight disruption in traffic flow to and from the lumber yard.
Cole Hardwood’s insurance company will be conducting an investigation.
The company had a similar fire in 2005. Cole said Tuesday’s blaze was the third of its kind at the facility.
• Kevin Lilly is news editor of the Pharos-Tribune. He can be reached at (574) 732-5117 or kevin.lilly@pharostribune.com
Local News
Related Photos
-
TWO-SIDED ATTACK: Firefighters battle a blaze inside this silo on the south side of the Cole Hardwood property on U.S. 24 west of Logansport. The fire on Tuesday took six hours to fully extinguish because of multiple levels inside the sawdust storage bin. P-T photo | Kevin Lilly
Discussion
Sawdust fire proves difficult to extinguish
Firefighters spend six hours dousing flames at Cole Hardwood
- Local News
-
- Daddy/Daughter Valentine Dance
-
Victory worth celebrating: United Way raises more than $600,000 for area organizations
Joe Johnson stood at the front of the room where a “small army” of community leaders had just been recognized for their work in raising more than $600,000 for United Way of Cass County. “Woah,” said the incoming campaign chairman. “This is scary.”
-
Accused rapist charged with felony in Arizona
A Logansport man out on bail on multiple sex-related charges was arrested last week in Arizona after police say he tried to attack his dad with a pair of kitchen knives.
-
Jurors: Galveston man not guilty of molest
A jury took only an hour Wednesday to decide that a Galveston man was not guilty of molesting a 9-year-old girl a decade ago.
-
Sen. Head to run for re-election
State Sen. Randy Head announced Wednesday he will seek re-election.
-
Retired Navy chief, former judge announce bids for local office
A former Cass Superior Court judge and a retired senior chief with the Navy announced their candidacies for local seats Wednesday.
-
Snowless savings: Warm weather lowers expenses
The unseasonably warm temperatures have allowed state and local road crews to perform roadwork usually conducted in the fall, lowered Logansport Municipal Utilities electric usage and saved all departments overtime pay for employees.
-
Logansport sees jump in grad rate
Logansport High School saw its graduation rate jump four percentage points in numbers released this week by the Indiana Department of Education.
-
Officials break ground on $1.1M Eel River Run
Contractors are set to begin work on the mile-long Eel River Run trail in downtown Logansport — the result of more than eight years of planning.
-
Fifth candidate files for county council
A longtime Logansport Municipal Utilities worker and former business owner is the first Democrat to file for county office in the coming primary election.
- More Local News Headlines
Obama Gives Education Waivers to 10 States
Giffords Aide to Run for Her Seat
LA School in Sex Abuse Scandal Reopens
Winter Slamming North Asia, Parts of Europe
Syrian Forces Renew Bombardment of Homs
States, Banks Reach Foreclosure-abuse Settlement
Raw Video: Italy's Mount Etna Bursts Into Life
Greeks March; Angry Despite Debt Deal
Raw Video: U.S. Pullout Celebration
Raw Video: Annual Empire State Building Run-Up
Man Killed in Courthouse Shootout
Air Force Airlines: Leaders Get Polished Service
Ga Girl Fights Off Kidnapper at Walmart
Nevada Highway Patrol, City Settle Beating Case
Homs Bombardment Continues, Global Outcry Grows
Raw Video: Dog Rescued From Icy Colo. Water
Skip the Coffee Cup and Inhale Your Caffeine Fix
